Read the Beforeitsnews.com story here. Advertise at Before It's News here.
Profile image
By Alton Parrish (Reporter)
Contributor profile | More stories
Story Views
Now:
Last hour:
Last 24 hours:
Total:

An Unconventional Car: No Engine, No Transmission, No Differential And Excellent Performance

% of readers think this story is Fact. Add your two cents.


This car has no engine, no transmission and no differential. It weighs half as much as a conventional car. Each of its four wheels has its own built-in electric battery-powered motor, meaning the car has the ability to make sharp turns and change direction very quickly.

An experimental four wheel independently actuated, lightweight electric vehicle.
Credit: Junmin Wang, Ohio State University

Without an exceptional traction and motion control system, however, this car would be quite difficult to drive, providing a driving experience vastly different from anything else on the road, and almost certainly more dangerous.

This is where Junmin Wang’s expertise comes in.

Wang, assistant professor of mechanical engineering at Ohio State University, and his team are designing algorithms for the vehicle’s onboard computer that will calculate and ensure motion control to keep the carstable and operating smoothly. The system, which receives and analyzes input data 100 times per second from the steering wheel, the gas pedal and brake, works out how each wheel should respond.

“Without it, the car is quite difficult to drive because the wheels are not coordinated,” says the National Science Foundation (NSF)-funded researcher, who also directs the university’s vehicle systems and control laboratory. “You feel like you are driving something uncontrollable. You could flip over, or travel along an undesired path, or cause a crash. But when the ‘controller’ is active, based on feedback loops, the vehicle motion can be controlled, just as the driver expects.”

 
Junmin Wang is an assistant professor of mechanical engineering at Ohio State University and principal investigator of the NSF-CAREER award.

Credit: Junmin Wang, Ohio State University

With a safe and reliable control system, this new electric vehicle ultimately should make the perfect in-city car. It’s efficient and maneuverable–and has no emissions. Because it is all electric, “you can use wind power or solar power, and contribute toward reducing our dependency on fossil oils,” Wang says.

The computer calculates exactly how much torque the car needs for each of its four wheels. Moreover, because each wheel is independent, “one wheel can be doing the braking, while another is doing the driving,” Wang says. “The computer gets signals from the driver from the steering wheel and pedal positions, then calculates the desired speed, or vehicle motion, based on a mathematical model.”

Wang’s work on the car began in 2009 with a grant from the Office of Naval Research Young Investigator Program. In February 2012 he received an NSF Faculty Early Career Development (CAREER) award, which supports junior faculty who exemplify the role of teacher-scholars through outstanding research, excellent education, and the integration of education and research within the context of the mission of their organization. He is receiving $400,000 over five years.

As part of the grant’s educational component, Wang’s lab hosted a summer program for high school students where, among other things, the teenagers disassembled and reassembled radio-controlled toyelectric cars to increase their understanding of their mechanics.

Additionally, students from the Columbus Metro School, a public STEM (science, technology, engineering, math) high school open to students from around the state, participated in research internships on the experimental car in Wang’s lab.

Wang’s research also receives funding from the Honda-Ohio State University Partnership Program and the Ohio State University Transportation Research Endowment Program.

The experimental car weighs only about 800 kg., or a little more than 1,750 pounds, which makes it energy efficient. The researchers retrofitted a commercially available utility terrain vehicle chassis and removed the engine, transmission and differential, then added a 7.5 kW electric motor to each wheel and a 15 kW lithium-ion battery pack. A single electrical cable connects the motors to a central computer. This type of car design, where each wheel has its own individual motor, is known as “four wheel independently actuated.”

The researchers tested the car and its controller on normal road conditions at the Transportation Research Center in East Liberty, Ohio, an independent automotive site for vehicle crash, emissions and durability testing. On roads with good conditions, the car followed a driver’s “desired” path within four inches.

To see how it performs on slippery roads, they brought the car to an empty west campus parking lot on a snowy day. The car maneuvered with an accuracy of up to eight inches, and the vehicle traction and motion control system prevented “fishtailing” through independent control of the left and right sides of the car.

The researchers, including doctoral student Rongrong Wang, described the car’s ability to follow a specific trajectory in a paper published in January 2013 in the journal Control Engineering Practice.

Wang can’t yet estimate the mileage for a single charge, since the car only has been driven during experimental testing. But he says the car provides “about 8 to 10 hours of driving on a single charge, although not continuously.”

Wang thinks it will take another five- to- 10 years before the car is ready for commercial use. The researchers still must fine-tune the computer algorithms and add more safety features. Wang says it is difficult to compare their test results to a conventional car, since the latter’s maneuverability is limited by thetransmission and differential systems that link the wheels together mechanically.

Nevertheless, he predicts that, ultimately, the research will produce an electric car that will be clean, fuel-efficient and “handle better than typical conventional cars,” he says.

Contacts and sources:
 Marlene Cimons
National Science Foundation

Junmin Wang 
Ohio State University



Before It’s News® is a community of individuals who report on what’s going on around them, from all around the world.

Anyone can join.
Anyone can contribute.
Anyone can become informed about their world.

"United We Stand" Click Here To Create Your Personal Citizen Journalist Account Today, Be Sure To Invite Your Friends.

Please Help Support BeforeitsNews by trying our Natural Health Products below!


Order by Phone at 888-809-8385 or online at https://mitocopper.com M - F 9am to 5pm EST

Order by Phone at 866-388-7003 or online at https://www.herbanomic.com M - F 9am to 5pm EST

Order by Phone at 866-388-7003 or online at https://www.herbanomics.com M - F 9am to 5pm EST


Humic & Fulvic Trace Minerals Complex - Nature's most important supplement! Vivid Dreams again!

HNEX HydroNano EXtracellular Water - Improve immune system health and reduce inflammation

Ultimate Clinical Potency Curcumin - Natural pain relief, reduce inflammation and so much more.

MitoCopper - Bioavailable Copper destroys pathogens and gives you more energy. (See Blood Video)
Oxy Powder - Natural Colon Cleanser!  Cleans out toxic buildup with oxygen! 
Nascent Iodine - Promotes detoxification, mental focus and thyroid health.
Smart Meter Cover -  Reduces Smart Meter radiation by 96%!  (See Video)

Report abuse

    Comments

    Your Comments
    Question   Razz  Sad   Evil  Exclaim  Smile  Redface  Biggrin  Surprised  Eek   Confused   Cool  LOL   Mad   Twisted  Rolleyes   Wink  Idea  Arrow  Neutral  Cry   Mr. Green

    Total 7 comments
    • Anonymous

      Until hot, cold, or salt gets to the electronics, then it is Mr Toads wild ride! :shock:

    • Paleocountry

      Or you could have one engine in front to run the front wheels and one in back to run the back wheels. It would be much easier to coordinate wheel pairs. And if one engine cut out, you would not have a sudden asynchronous force on the car.

    • Anonymous

      We already have so many inventions about electric, water, free energy cars but elite will not allowed to build it — They will not make MONEY.

      • DOOMSDAY!

        OH ROFL! OH ROFL! :lol: :lol: :lol: :lol: :lol: :lol: :lol: :lol: :lol: :lol: :lol: :lol: :lol: :lol:

    • McElchap

      Prof. Wang’s little vehicle may be ingeniously clever, but me thinks it is way too complicated, and as such, would be a maintenance nightmare for car owners. I had a 1995 Geo Metro, a Suzuki licensed to GM, with a tiny 3 cylinder engine that was very fuel efficient for 15 years until I sold it. It was in the same weight class as Wang’s little “car”. And as far as “zero emissions” go, what about the big commercial power plants that will be recharging the batteries? Wang’s car will simply transfer emissions from vehicle to coal, oil, gas, and nuclear power plants. Very few cars will be charged by wind or solar power. Sorry, Wang. :idea:

    • Thane36425

      This design has been tried many times and has almost always failed. The only exception that I can think of are some of the larger dump trucks at big mining sites. It doesn’t seem to translate well to passenger vehicles and their speeds. Reliability and short lifespans have also been issues.

    • Anonymous

      This guy thinks he is so smart and doing such great things for humanity but in reality he is just a big Wang.

    MOST RECENT
    Load more ...

    SignUp

    Login

    Newsletter

    Email this story
    Email this story

    If you really want to ban this commenter, please write down the reason:

    If you really want to disable all recommended stories, click on OK button. After that, you will be redirect to your options page.