Read the story here. Advertise at Before It's News here.
Profile image
By Appalachian Voices
Contributor profile | More stories
Story Views
Last hour:
Last 24 hours:

Uranium Refinement Plans Moving Forward in Erwin, Tenn.

% of readers think this story is Fact. Add your two cents.

By Lorelei Goff

Person speaks from podium

Erwin Citizens Awareness Network President Linda Modica Cataldo delivered a message urging “determined legal pressure on the Nuclear Regulatory Commission” to halt a license amendment request by Nuclear Fuels Services to begin a new uranium processing project. Cataldo spoke during a service at Abingdon United Methodist Church on January 14 as ECAN sought a public hearing on the issue. The petition for a hearing was denied on January 23. Photo by Reece Hill

A federal board is allowing a nuclear fuels company to move forward with their plans to begin producing refined uranium in Erwin, Tennessee, despite opposition from a local organization.

An Atomic Safety and Licensing Board, a trial-level body within the Nuclear Regulatory Commission that determines rights and obligations between disputing parties in agency licensing and enforcement cases, rejected a hearing petition from Erwin Citizens Awareness Network, a local advocacy group, on January 30. Through the petition, ECAN sought to intervene in a license amendment request by Nuclear Fuels Services Inc. The company is seeking the amendment in order to refine highly enriched uranium metal at its plant in Erwin. Uranium metal can be used for a variety of purposes, including weapons, nuclear power reactors and medical applications.

Nuclear Fuels Services is the sole facility licensed to process highly enriched uranium to make nuclear fuel for reactors used to power the U.S. submarine fleet and aircraft carriers. NFS also downblends highly enriched uranium to produce low-enriched uranium suitable for use as commercial nuclear reactor fuel and for national defense programs. Downblending is a process in which highly enriched uranium is mixed with natural uranium to make low-enriched uranium.

NFS is seeking permission to begin refining highly enriched uranium as soon as construction to accommodate the new process is completed within the plant. The new product line is intended to fill a gap in production while the aging uranium processing facility in the Y-12 National Security Complex in Oak Ridge, Tennessee, which is typically responsible for this process, is replaced by a new facility.

The new refining process would recycle existing material. The United States has not produced highly enriched uranium for nuclear weapons since 1964, according to an emailed statement from a National Nuclear Security Administration spokesperson.

“[Highly enriched uranium] in the U.S. inventory is finite and irreplaceable and is therefore required to be recycled for use in support of numerous national security missions, including NNSA’s Defense Programs, Naval Reactors, and Defense Nuclear Nonproliferation Programs,” wrote the spokesperson. “NFS will recycle [highly enriched uranium] through conversion of oxide into metal. While Y-12 will continue to purify metal, the contract with NFS closes a capability gap for oxide-to-metal conversion, which will temporarily be unavailable at Y-12 starting in July 2023.

“The contract with NFS is a bridging strategy as NNSA’s long-term plan is for Y-12 to resume converting uranium oxide to metal in Building 9215 in the mid- to late-2030s.”

The Nuclear Regulatory Commission is responsible for oversight of NFS, which is one of many subsidiaries owned by parent company BWX Technologies, Inc. NFS requested its existing license be amended to allow the plant to provide additional uranium purification and conversion services under an existing $57.5 million federal contract.

The contract directs NFS to design and license a process for uranium purification and conversion to highly enriched uranium metal, according to an emailed statement from NRC Public Affairs Officer Dave Gaspersen. The license amendment would authorize NFS to perform that purification process.

“The National Nuclear Security Administration (NNSA) added approximately $10 million of scope to the phase 1 contract. NFS has submitted a proposal to NNSA for phase 2 of the contract,” said Nuclear Fuels Services Communications Manager Laura Bailey in an emailed statement. “We anticipate a response later this year. At that time, we would begin construction within our facility.”

Structural construction on the main processing building for the new Y-12 facility at Oak Ridge National Laboratory was completed in 2021. However, delays caused by COVID and supply chain issues have moved the projected date for the new uranium processing facility at Y-12 to begin operating from 2025 to 2027.

The Erwin Citizens Awareness Network’s petition cited four objections, including that a nuclear weapons proliferation assessment hasn’t been completed for the new refinement process and that the purpose and need for the project are described too narrowly. The group also cited concerns about historical and ongoing chemical and radiological contamination of groundwater, soil and air, and said that the lack of stringent quality assurance requirements has failed to create a safety culture that protects the public, workers and the environment.

The petition “failed to show that any of its four contentions are admissible under the governing standards,” according to a memorandum and order issued by the panel on January 30 that denied a hearing requested by the community group.

Environmental and Safety Concerns Raised

Barbara O’Neil, vice president of Erwin Citizens Awareness Network, says she has compiled documents that show more than 350 violations at Nuclear Fuels Services since it began operating.

The plant made international news in 2006 when about 9 gallons of highly enriched uranium solution spilled near an elevator pit, where it could have collected and resulted in a nuclear reaction.

The Nuclear Fuels Services Inc. logo and a map showing its location in Tennessee

Nuclear Fuels Services, Inc., located in Erwin, Tennessee, is moving forward with plans to begin refining highly enriched uranium. Logo courtesy of Nuclear Fuels Services

The plant shut down for seven months and was required to undergo frequent inspections. According to Erwin Citizens Awareness Network President Linda Cataldo Modica, two resident inspectors were assigned to the site ”for years afterward.”

“And by the way, this was all hushed up,” Modica says. “The public didn’t know about it until the then-chairman of the Nuclear Regulatory Commission, it was [Gregory B. Jaczko], demanded that the NRC report it to the Congress. One of the congressmembers said it was through dumb luck that there wasn’t a major accident.”

Modica asserts the plant’s infrastructure and machinery is too old to safely continue downblending or enriching uranium. The plant was established in 1957 and began nuclear fuel fabrication and uranium recovery operations in 1959.

“The closest thing to an environmental impact study was done in the early years of the Nuclear Regulatory Commission and it was called an environmental impact appraisal,” Modica says. “At that point, the plant’s life expectancy was estimated to be 30 years.”

Modica describes the amendment request as a proposal for a hazardous process to be conducted by a company with a history of safety and environmental violations.

“And, by the way, Erwin Citizens Awareness Network’s petition for a hearing was denied on the same afternoon when Nuclear Fuel Services, that morning, had an explosion that injured five workers and sent two of them to the hospital,” says Modica.

Terry Lodge, an attorney for the local group, says testing required under current regulations is inadequate. He points out that there’s been “a great deal” of radioactive as well as chemical pollution of soil and groundwater beneath and in the vicinity of the plant over its 65-plus years of operation.

“The company does not deny that,” Lodge says. “They say, however, that there is no substantial public health risk because limits imposed by (the Tennessee Department of Health and the NRC) have not been exceeded.

“Our real focus there is that there are quite a few radionuclides that are not measured, not monitored, not looked for in the water and that there’s a cumulative effect when you have long-term, long-lived radiation present in the water supplies.”

Lodge filed an appeal on February 24. The Nuclear Regulatory Commission staff and Nuclear Fuels Services have until March 21 to respond to the appeal. The Atomic Safety and Licensing Board will likely issue its ruling on the appeal within two to three months of the March 21 deadline.

In addition to the environmental and safety concerns, ECAN asserts that public comments emailed to the NRC regarding the petition were disregarded by the Atomic Safety and Licensing Board Panel.

The Appalachian Peace Education Center, a local nonprofit organization, plans to hold a People’s Hearing about NFS’s license amendment request on March 26 at 2 p.m., at the Johnson City Public Library in Johnson City, Tenn. Speakers will include “experts in nuclear safety, in nuclear destruction and nuclear pollution, as well as from community members from the affected area surrounding NFS,” according to an emailed statement from Appalachian Peace Education Center.

The post Uranium Refinement Plans Moving Forward in Erwin, Tenn. appeared first on Appalachian Voices.

Protecting the Central and Southern Appalachian Mountain Region


Before It’s News® is a community of individuals who report on what’s going on around them, from all around the world.

Anyone can join.
Anyone can contribute.
Anyone can become informed about their world.

"United We Stand" Click Here To Create Your Personal Citizen Journalist Account Today, Be Sure To Invite Your Friends.

Please Help Support BeforeitsNews by trying our Natural Health Products below!

Order by Phone at 888-809-8385 or online at M - F 9am to 5pm EST

Order by Phone at 866-388-7003 or online at M - F 9am to 5pm EST

Order by Phone at 866-388-7003 or online at M - F 9am to 5pm EST

Humic & Fulvic Trace Minerals Complex - Nature's most important supplement! Vivid Dreams again!

HNEX HydroNano EXtracellular Water - Improve immune system health and reduce inflammation.

Ultimate Clinical Potency Curcumin - Natural pain relief, reduce inflammation and so much more.

MitoCopper - Bioavailable Copper destroys pathogens and gives you more energy. (See Blood Video)

Oxy Powder - Natural Colon Cleanser!  Cleans out toxic buildup with oxygen!

Nascent Iodine - Promotes detoxification, mental focus and thyroid health.

Smart Meter Cover -  Reduces Smart Meter radiation by 96%! (See Video).

Report abuse


    Your Comments
    Question   Razz  Sad   Evil  Exclaim  Smile  Redface  Biggrin  Surprised  Eek   Confused   Cool  LOL   Mad   Twisted  Rolleyes   Wink  Idea  Arrow  Neutral  Cry   Mr. Green

    Load more ...




    Email this story
    Email this story

    If you really want to ban this commenter, please write down the reason:

    If you really want to disable all recommended stories, click on OK button. After that, you will be redirect to your options page.