Read the story here. Advertise at Before It's News here.
Profile image
By Claude Nelson
Contributor profile | More stories
Story Views
Last hour:
Last 24 hours:

7 Deadly Canning Mistakes Even Smart People Make

% of readers think this story is Fact. Add your two cents.

If you’re ever forced back on your own resources for the long term, home canning is going to be an essential skill. You can’t grow your own vegetables all year round; there’s a growing season followed by a harvest season, and how long they are and when they end are determined by the climate. Once you’ve harvested your crop for the year, that’s it; there won’t be any more until next year.

To keep your diet healthy through the year you’re going to have to preserve the bulk of what you’ve grown for later use. The simplest way is by freezing, but what if power has become unreliable? Even a few hours’ blackout could spoil everything you have stored. The only reliable way to preserve your own vegetables is canning, and that means it’s a skill everyone should have.

Canning isn’t a complicated process, and it doesn’t need much in the way of equipment. As long as you have suitable jars, lids and a way to boil water you’re all set. What it does need, however, is attention to detail. If you’re not careful you could end up with food that spoils in the jar – or becomes a deadly hazard.

Related: 13 Myths and Facts About Canned Foods

#1 Principles of Canning

Food spoils because oxygen breaks down some of the nutrients it contains, and microorganisms grow and feed on it. Canning preserves the food by protecting it from both of these threats. If the food is inside the jar, and the oxygen and microorganisms are outside, they can’t get in to spoil it. Right?

Well, kind of. That’s the basic idea, but it’s not as simple as just getting a good seal when you put the lid on. There’s always going to be some oxygen trapped inside the jar, but if there’s too much it could be enough to spoil the contents before it’s all used up. Too much oxygen will also let bacteria or mold keep growing. It’s essential to get as much air out of your jars as possible before you seal them.

Unfortunately, that can cause another, and much more serious, problem. Most bacteria won’t grow if there isn’t enough oxygen in their environment, but there are a few that won’t grow if there’s too much. Some of them are harmless, some will give you an upset stomach, but one of them is potentially deadly – and it grows like wildfire in food that hasn’t been properly canned.

This microbe is a bacteria called Clostridium botulinum. It’s very common in soil, and is found all over the world. Most vegetables are exposed to the bacteria as they grow. Normally this isn’t a problem, though. In a normal environment C. botulinumis dormant, because it can’t grow if there’s more than about two percent oxygen in the air. Put it somewhere with little or no oxygen, however, and it will start to grow rapidly – and as it grows it produces a neurotoxin. The common name for this is botox, and it’s what some people get injected into their face to get rid of wrinkles. But wrinkle treatment uses tiny amounts of highly diluted botox, and here’s why:

Botox is the most poisonous substance ever discovered – far more deadly than cyanide, rattlesnake venom or military nerve agents. An ounce of pure Botox will kill 175,000 people – and a fraction of a milligram in a jar of contaminated food is all it takes to kill you.

Properly canned food is safe from botulinum contamination – but do it wrong and you’re playing Russian Roulette. Sooner or later, unless you take the right precautions, you’ll open a jar that has a colony of C. botulinum growing inside. If you notice the symptoms in time and can get to a good hospital it can be treated easily enough – but in a SHTF scenario you’re dead.

When you’re relying on your own resources the only defense against botulism is to can your food properly and prevent the bacteria getting a hold. The way to do that is to avoid these deadly mistakes:

#2 Canning Bacteria

The fewer bacteria go into the jar along with your fruit or vegetables, the lower the risk of a dangerous infection. That means you need to get the food as clean as possible before it goes into the jar. Anything that grows above ground should be thoroughly washed, but vegetables that are directly exposed to soil probably won’t be clean enough even after scrubbing. Peel them instead, to make sure all soil residue and bacteria are removed. Tomatoes should also be peeled. For extra safety, blanching will kill many bacteria.

Once you’ve got your produce clean, don’t recontaminate it. Jars, lids and any utensils you’re using all need to be sterilized. Clean enough for normal food preparation doesn’t mean clean enough for canning. When you’re cooking dinner and a few bacteria slip through it doesn’t matter much – they won’t have time to grow. It’s a different ball game when you’re planning to store canned food for months or years. Even if there are only a few microbes when you seal the jar, there can be trillions by the time you eat the contents.

Related: How to Tell When Your Canned Foods Become Spoiled?

#3 Forgetting the Acid

C. botulinum grows best in a non-acidic environment. Acid slows the bacteria’s growth and can even destroy them. Unfortunately, most of the vegetables popular with home canners have a low acid content, making them more likely to hostbotulinum. Tomatoes are one exception; there are low-acid varieties, but for canning you should avoid those. With other vegetables, consider adding some acid to the mix. Vinegar or lemon juice are good options that can also enhance the flavor. You don’t need to add enough to pickle the contents, but if you can push the pH of the liquid below 4.6 that will do a lot to keep your food safe.

With the exception of bananas and some varieties of apples and pears, fruits have a much higher acid content than vegetables. This doesn’t eliminate the risk of botulism, but it does reduce it.

30 Lost Ways of Survival from 1880 We Should All Learn​

#4 Keeping it Cool

Heat is one of the most reliable ways to destroy bacteria, including C. botulinum – if you use a high enough temperature for long enough. Fruit and tomatoes – acidic foods – can be safely canned using boiling water, because the botulism risk is low anyway. The same goes for other vegetables that have had acid added. Simple boiling doesn’t give any safety margin for less acidic foods, though. If you’re canning meat or low-acid vegetables the only way to ensure safety is to heat them to at least 240°F, and that means using a pressure canner. If you’re canning without electricity a pressure cooker can be used. A USDA-approved pressure cooker should boil water at 250°F, which gives a good safety margin.

#5 Bad Seals

Check the seal on every jar before you store it. Press metal lids with a finger; if there’s any give in it, the jar isn’t properly sealed. For screw band type lids, you should remove the band and pull gently at the lid. If it’s sealed it will stay on the jar; if it comes off, refrigerate the contents or eat them right away.

#6 Sloppy Storage

Storing your canned food in the wrong place can quickly shorten its life, lower its quality and even make it dangerous. On the other hand, correct storage will preserve it and keep it safe.

Clear glass jars let light in, and that can discolor many canned foods. It’s not a serious problem but it does make them less appetizing. Store your jars somewhere dark – or, at the very least, out of direct sunlight.

Look for a cool place. Heat is essential during the actual canning process, but once your jars are sealed it becomes an enemy. Temperatures above 75°F can make vegetables turn mushy, and they also encourage microorganisms to grow.

Dampness is also bad news. Glass is immune to it, but lids and screw bands can rust. It’ll take a while for them to rust right through, but rusty edges can start leaking tiny quantities of air. That won’t help botulinum, but there are plenty other bacteria and molds that can spoil your food and make you ill.

H2O Dynamo – The Awesome Device That Turns Air Into Fresh Water!​​

#7 Forgetting to Check

Don’t just open a jar of canned food and dig in with your spoon. Check the container before opening; is anything cracked or distorted? Do the contents look discolored? Are there any signs of leaks? If you spot any of those things throw the food away. When you open the jar there should be a rush of air as the vacuum inside breaks; if there isn’t then the seal might have failed, and the contents aren’t safe. Also get rid of anything that spurts liquid or foam when you open it.

Any sign of mold inside the jar means it’s either leaked or wasn’t properly sterilized to start with. The mold itself could make you sick but it’s also an indicator that bacteria could be – and probably is – growing in there too. Throw it away.

This article first appeard on


What Should You Do With Your Canned Foods After the Expiration Date?

My Grandma’s Method of Canning Eggplant

How to Can Simple Tomato Sauce from Fresh Tomatoes and Peppers

Organifi – The Ultimate Prepper Juice to Stockpile

Before It’s News® is a community of individuals who report on what’s going on around them, from all around the world.

Anyone can join.
Anyone can contribute.
Anyone can become informed about their world.

"United We Stand" Click Here To Create Your Personal Citizen Journalist Account Today, Be Sure To Invite Your Friends.

Please Help Support BeforeitsNews by trying our Natural Health Products below!

Order by Phone at 888-809-8385 or online at M - F 9am to 5pm EST

Order by Phone at 866-388-7003 or online at M - F 9am to 5pm EST

Order by Phone at 866-388-7003 or online at M - F 9am to 5pm EST

Humic & Fulvic Trace Minerals Complex - Nature's most important supplement! Vivid Dreams again!

HNEX HydroNano EXtracellular Water - Improve immune system health and reduce inflammation.

Ultimate Clinical Potency Curcumin - Natural pain relief, reduce inflammation and so much more.

MitoCopper - Bioavailable Copper destroys pathogens and gives you more energy. (See Blood Video)

Oxy Powder - Natural Colon Cleanser!  Cleans out toxic buildup with oxygen!

Nascent Iodine - Promotes detoxification, mental focus and thyroid health.

Smart Meter Cover -  Reduces Smart Meter radiation by 96%! (See Video).

Report abuse


    Your Comments
    Question   Razz  Sad   Evil  Exclaim  Smile  Redface  Biggrin  Surprised  Eek   Confused   Cool  LOL   Mad   Twisted  Rolleyes   Wink  Idea  Arrow  Neutral  Cry   Mr. Green

    Load more ...




    Email this story
    Email this story

    If you really want to ban this commenter, please write down the reason:

    If you really want to disable all recommended stories, click on OK button. After that, you will be redirect to your options page.